Faults:

Transmission failure at 170000 miles.

EGR valve replaced once and cleaned once.

Radiator leaking at 197000 miles.

All doors have broken. I have only bothered to fix back door and driver's door.

General Comments:

This mid-sized van is a real solid delivery vehicle.

I find the 4.3 engine to be powerful and bulletproof.

Handling is what I'd expect from a van on a truck platform.

Faults:

Air Compressor and clutch went out two months after ownership at 100,000 miles. We are still trying to get this fixed.

Driver's side power window motor went out. Found one at a junk yard for $20.

The drivers side seat leans to the left a little bit, making for a soar back after a long trip.

General Comments:

Overall, we love our van.

When we went to the junk yard to get our window motor, we saw a ton of vans just like ours out there. Many of them had up to 600,000 miles on them!

It's a work horse. We've never wondered if it would just give out.

However, it can be top heavy and I've been a little bit nervous driving it in windy weather on the interstate.

Faults:

Air Conditioner Compressor went out at 41,000 miles. I had the extended warranty so it was fixed for free, but would have been about $1100.00 to fix.

Radiator leaked at 122,000 and I replaced the radiator, water pump, belts and hoses at that time. I did the work myself and had no problems.

EGR Valve gummed up at 130,000 and had to be fixed to pass emissions, $235.00.

Windshield wiper circuit board had to be re-soldered at 75,000 miles. I soldered it myself.

Drivers side window motor went out this week, 167,000 miles and I had to replace it today. Motor - 59.00.

Rear air is still out, do not know when it stopped working.

Has a small leak in the heater core so I will have to replace it soon.

Rear end pinion seal went out at 110,000 miles. 85.00 to repair.

Inner and outer tie rod ends were cheap from the factory and had to be replaced at 55,000 miles.

General Comments:

This is the best vehicle I have ever owned. I bought it new and put over 167,000 miles on it with very little maintenance. Changed the oil every three thousand miles. I tow an 18' ski boat with this van from Georgia to Florida frequently and it has no problems towing. The engine is strong and the van has held up to two kids well. I am in the process of replacing the carpet and having the interior done now. I plan to drive this thing until the wheels fall off!!

Faults:

Had a hub go out on front, left wheel. I've heard that this is very unusual and cost about $600 to fix with a part from the salvage yard.

Lots of rattles.

Driver's door handle broken.

Driver's power door unlock no longer works.

General Comments:

I am impressed by how strong the engine and transmission run and overall it has been a fairly dependable vehicle.

But this is built on a truck chassis and it feels like it. It has to be the roughest riding van on the market and I am sure that is why it has all of the rattles.

Terrible gas mileage - about 16-17 mpg.

My van is All Wheel Drive and it gets around great, even on ice. That is one thing I am going to miss when I sell this.

Faults:

Had one belt replaced.

General Comments:

I have been pleased so far and have never been stranded. Tires wear quickly and poor visibility in the rear due to double doors. Next time I would choose a solid back window. Moderate gas mileage.