2003 Ford Fusion 1 1.4 Tdci

Summary:

Poor

Faults:

Poor fuel consumption.

Flat spots on acceleration at 1300 and 3000 RPM, engine would die on move off.

New engine management system computer.

Clutch replaced.

New rear wheel bearing.

New steering wheel, cover wearing.

Headlights replaced, beam adjusters would not work.

Blown Turbo.

Fuel leak from from hand primer in engine compartment.

Power assisted steering belt tensioner replaced, knocking.

Flywheel and clutch replaced.

Noisy rear dampers.

Electronic accelerator control failure.

New accelerator fitted.

New battery fitted.

New fuel rail fitted.

General Comments:

A good vehicle spoiled by unreliable components.

I think thirty five visits to the dealer in twenty two months is a poor reflection on the quality of this particular vehicle.

Would you buy another car from this manufacturer? Don't Know

Review Date: 1st June, 2005

2003 Ford Fusion 2 1.4 16v

Summary:

A good car, but bland to drive

Faults:

Performance and fuel economy are erratic (no fault found by dealer).

General Comments:

The quality of materials used for the interior is fairly poor. The upholstery and carpet is difficult to keep clean.

Handling is very good, steering very responsive with an excellent turning circle which, along with superb all round visibility, makes parking very easy.

Extremely spacious inside considering it's based on a Fiesta.

Would you buy another car from this manufacturer? Don't Know

Review Date: 30th January, 2005

6th Feb 2007, 14:24

Jan 2004 Ford Fusion 2,not a days trouble in the 2 years 3 months I have owned it, then 1 day after the manufacturers warranty ran out my a switch in the durashift gearbox packed up leaving me with a £900.00 bill from Fords. getting it fixed and getting rid!

In reply to 6th Feb 2007, 14:24

25th Jul 2023, 15:24

The auto boxes on these cars were terrible. I had a manual one and the rest of the car was not much better either. I also struggled for good fuel economy. Drove carefully and serviced on time, still barely cracked 37 mpg, the official figure is 42 but never saw that even on longer drives!

2003 Ford Fusion 2 16v petrol

Summary:

Not at all as good as hoped for

Faults:

Needed a new clutch.

Needed a new exhaust.

Have trouble starting the engine.

General Comments:

The seats are very comfortable.

Easy access to seats, ideal for disabled passengers.

Fuel consumption is extremely poor, average of 21 mpg rural and 40 mpg motorway driving.

The dials and clocks on the dashboard is clearly visible.

Road holding is not too good.

Would you buy another car from this manufacturer? No

Review Date: 9th December, 2004